Revision as of 14:21, 17 March 2009

General Information about the Forklift

Purchased refurbished Clark T15 in August 2006.
Vendor: Norlift
Sales: Kevin Hannum
- Norlift 503-659-LIFT
Preventative Maintenance (PM) March/September
- Ken Ferguson 503-519-1541
Repairs call Premier Repairservice
- 503-691-1430

Forklift Operator Training

Before a staff member may drive the forklift they must be trained. They have to fill out (with their buddy) the Forklift Training Checklist

current certified drivers and date of training:
- Cliff
  - 11/06/06
  - trained by Norlift
- Dave
  - 11/06/06
  - trained by Norlift
- Sergio
  - 11/06/06
  - trained by Norlift
- Liane
  - 11/06/06
  - trained by Norlift
- Darryl
  - trained by Cliff

@@ Line 1: / Line 1: @@
-Purchased refurbished Clark T15 in August 2006.
+'''General Information about the Forklift'''
-Vendor: Norlift
+* Purchased refurbished Clark T15 in August 2006.
-PM contract: see RT ticket 5562
+* Vendor: Norlift
+* Sales: Kevin Hannum
+** Norlift 503-659-LIFT
+* Preventative Maintenance (PM) March/September
+** Ken Ferguson 503-519-1541
+* Repairs call Premier Repairservice
+** 503-691-1430
-==Daily checklist==
+[[Forklift Maintenance]]
-*'''Battery Water Level'''
-Check water level every morning before driving.
-If adding water, record it on the Forklift Maintenance Calendar,
-which is on the wall above the charger.
-*'''Wheels'''
-Remove nails or other object that get stuck in the rubber wheels.
-*'''Forks'''
-Make sure forks are locked in position.
-==Weekly checklist and maintainance==
-* '''Charging the Battery'''
-When the charge is below 30%, it SHOULD be charged,
-when the charge is below 20%, it MUST be charged.
-Always check the water level before charging,
-even if you checked it that morning.
-Deep discharge before charging will prolong battery life
-& prevent "memory" problems.
-How does the charger work? =
-There is no "ON" switch, just plug it into the battery,
-& wait about 5 seconds, you'll hear the hum.  It will stop
-by itself.
-There is a "STOP" switch if we wanna stop the charge for any reason.
-* '''Equalizing'''
-Every 5th charge "EQUALIZE"  with the normal charge by pushing the equalize button on the charger. If you're not sure how many charges since last "equalize" check calendar above charger.
-*'''Water'''
-Check the water level in each cell '''AFTER''' charging, & after the
-water has cooled a bit - like the morning after the charge.
-Adding tap water - with all its minerals & junk - will ''shorten''
-battery life.
-== To charge the battery ==
-# shut down the forklift completely
-# open up and fold back the seat lid over the battery
-# Always check the water level before charging, even if you checked it that morning.
-# unplug the huge cable from the forklift and plug it into the charger
-# wait 5 seconds, you'll hear a hum when charger is working
-# the charger will shut down by it self, reconnect big cable to battery, and fold down the seat. Please make sure the cable doesn't get pinched on the left side of the seat and is fully inserted.
-'''Note: charging the battery produces hydrogen gas bubbles coming out of the battery.  DO NOT smoke near the battery when the seat lid is up, especially not while charging is going on.
-'''
-* '''Acid'''
-We do not refill Acid on the battery. This should be done at the forklift repairshop. The PM contract  mechanic will recommend it if needed.
-=Forklift Vendor=
-==Norlift==
-*Sales: Kevin Hannum
-**503-659-LIFT
-**cell   503 209 0987
-**Office 503 659 5438
 = Forklift Operator Training =
-Before a staff member may drive the they must be instructed and fill out (with there buddy) the [[Forklift Training Checklist]]
+Before a staff member may drive the forklift they must be trained. They have to  fill out (with their buddy) the [[Forklift Training Checklist]]
 * current certified drivers and date of training:

Difference between revisions of "Forklift"

Revision as of 14:21, 17 March 2009

Forklift Operator Training

Navigation menu

Search