Difference between revisions of "Forklift"

From FreekiWiki
Jump to navigation Jump to search
m
 
(41 intermediate revisions by 7 users not shown)
Line 1: Line 1:
−
== Maintaining the forklift battery ==
+
{{Migrated}}
 +
[https://docs.google.com/document/d/1CYD2i4wfzQAw8IRdfhSEiGvidvNaTSRqUaeKW4gqZdk/edit?usp=sharing Link]
  
−
=== Once a week (pick one day every week!) ===
+
'''General Information about the Forklift'''
−
* Lift the seat lid and hold it up with the red latch
 
−
* Ideally do the following with rubber gloves to protect your hands
 
−
* Look inside each of the yellow caps to see the battery acid level
 
−
* Add distilled water to each hole so the level comes just to the bottom of the yellow cap tube.  Too much and the battery will spew sulferic acid all over the battery top when it charges. Not enough and the level will go down and uncover the battery plates, causing them to oxidize extra fast.
 
−
* Be sure to use DISTILLED water and a small plastic funnel
 
−
* Clean up with paper towels and wash your hands thoroughly with lots of soap to clean off the acid vapors and such.
 
  
−
=== To charge the battery ===
+
* Purchased refurbished Clark T15 in August 2006.
−
# shut down the forklift completely
+
* Vendor: Norlift
−
# open up and latch the seat lid over the battery
+
* Sales: Kevin Hannum
−
# make sure the charger is off (at zero)
+
** Norlift 503-659-LIFT
−
# unplug the huge cable from the forklift and plug it into the charger
+
* Preventative Maintenance (PM) June/December
−
# turn the charger past 6 hours and then set the charging time to the length of time that the forklift was actually used.  This can be done at the end of the day.
+
** Ken Ferguson 503-519-1541
−
# After the charger time is up.  Unplug the battery from the charger, plug it back into the forklift, close the seat cover and your finished.
+
* Repairs call Premier Repairservice
 +
** As of October 2011, the technician is Sean.
 +
** 503-691-1430
  
−
'''Note: charging the battery produces hydrogen gas bubbles coming out of the battery.  DO NOT smoke near the battery when the seat lid is up, especially not while charging is going on.
+
= Forklift Maintenance =
−
'''
+
[[Forklift Maintenance for Clark T15]]
−
== Forklift Mechanics ==  
 
−
; Premier Lift Truck Service, Inc.
 
−
: Out of Tualitin. They sold us out battery and can work on the battery or charger if issues arise. Phone: (503) 691-1430. Contact name: Monty.
 
  
 +
= Forklift Operator Training =
 +
Before a staff member may drive the forklift they must be trained. They have to  fill out (with their buddy) the [[Forklift Training Checklist]]
 +
 +
* current certified drivers and date of training:
 +
** Cliff
 +
*** Trained by Norlift on 11/06/06 (Train the Trainer Program)
 +
*** Re-Certified by Darryl on 11/12/09
 +
** Liane
 +
*** Trained by Norlift on 11/06/06 (Train the Trainer Program)
 +
*** Re-Certified by Cliff on 11/12/09
 +
** Darryl
 +
*** Trained by Cliff in October 2007
 +
*** Re-Certified by Liane on 11/12/09
 +
** John A
 +
*** Trained by Cliff May 2011
 +
*** Certified by Cliff May 2011
 +
                       
 
[[Category:Recycling]]
 
[[Category:Recycling]]
 +
[[Category:Procedures]]
 +
[[Category: Environmental Management System]]

Latest revision as of 12:01, 19 July 2014

deletion

This page has been migrated to a document on Free Geek's Google Drive.

Information remaining behind may no longer be relevant.

MIGRATOR:

When you have tagged this page as migrated,
please add a link to the new document on Google Drive.

(Link to new page immediately below.)


Link

General Information about the Forklift

  • Purchased refurbished Clark T15 in August 2006.
  • Vendor: Norlift
  • Sales: Kevin Hannum
    • Norlift 503-659-LIFT
  • Preventative Maintenance (PM) June/December
    • Ken Ferguson 503-519-1541
  • Repairs call Premier Repairservice
    • As of October 2011, the technician is Sean.
    • 503-691-1430

Forklift Maintenance

Forklift Maintenance for Clark T15

Forklift Operator Training

Before a staff member may drive the forklift they must be trained. They have to fill out (with their buddy) the Forklift Training Checklist

  • current certified drivers and date of training:
    • Cliff
      • Trained by Norlift on 11/06/06 (Train the Trainer Program)
      • Re-Certified by Darryl on 11/12/09
    • Liane
      • Trained by Norlift on 11/06/06 (Train the Trainer Program)
      • Re-Certified by Cliff on 11/12/09
    • Darryl
      • Trained by Cliff in October 2007
      • Re-Certified by Liane on 11/12/09
    • John A
      • Trained by Cliff May 2011
      • Certified by Cliff May 2011
Retrieved from "http://wiki.freegeek.org/index.php?title=Forklift&oldid=70733"