Difference between revisions of "Forklift"

From FreekiWiki
Jump to navigation Jump to search
 
(33 intermediate revisions by 6 users not shown)
Line 1: Line 1:
−
== Maintaining the forklift battery ==
+
{{Migrated}}
 +
[https://docs.google.com/document/d/1CYD2i4wfzQAw8IRdfhSEiGvidvNaTSRqUaeKW4gqZdk/edit?usp=sharing Link]
  
−
=Charging=
+
'''General Information about the Forklift'''
−
Let the charge get down to or below 20%, then charge.
 
−
Deep discharge before charging will prolong battery life
 
−
& prevent "memory" problems.
 
  
−
How does the charger work? =
+
* Purchased refurbished Clark T15 in August 2006.
−
There is no "ON" switch, just plug it into the battery,
+
* Vendor: Norlift
−
& wait about 5 seconds, you'll hear the hum. It will stop
+
* Sales: Kevin Hannum
−
by itself.
+
** Norlift 503-659-LIFT
 +
* Preventative Maintenance (PM) June/December
 +
** Ken Ferguson 503-519-1541
 +
* Repairs call Premier Repairservice
 +
** As of October 2011, the technician is Sean.
 +
** 503-691-1430
  
−
There is a "STOP" switch if we wanna stop the charge for any reason.
+
= Forklift Maintenance =
 +
[[Forklift Maintenance for Clark T15]]
  
−
Monthly, we do an "EQUALIZE" charge instead of the normal charge,
+
= Forklift Operator Training =
−
there is a button to switch over to that kind of charge.
+
Before a staff member may drive the forklift they must be trained. They have to fill out (with their buddy) the [[Forklift Training Checklist]]
−
It is supposed to take a few hours longer, but we charge overnight
 
−
so who cares?
 
  
−
A possible schedule would be the 1st charge of a calendar month,
+
* current certified drivers and date of training:
−
since we will not charge on any specific days.
+
** Cliff
−
 
+
*** Trained by Norlift on 11/06/06 (Train the Trainer Program)
−
Check the water level in each cell '''AFTER''' charging, & after the
+
*** Re-Certified by Darryl on 11/12/09
−
water has cooled a bit - like the morning after the charge.
+
** Liane
−
Adding tap water - with all its minerals & junk - will ''shorten''
+
*** Trained by Norlift on 11/06/06 (Train the Trainer Program)
−
battery life.
+
*** Re-Certified by Cliff on 11/12/09
−
 
+
** Darryl
−
=== To charge the battery ===
+
*** Trained by Cliff in October 2007
−
# shut down the forklift completely
+
*** Re-Certified by Liane on 11/12/09
−
# open up and latch the seat lid over the battery
+
** John A
−
# make sure the charger is off (at zero)
+
*** Trained by Cliff May 2011
−
# unplug the huge cable from the forklift and plug it into the charger
+
*** Certified by Cliff May 2011
−
# turn the charger past 6 hours and then set the charging time to the length of time that the forklift was actually used.  This can be done at the end of the day.
 
−
# After the charger time is up.  Unplug the battery from the charger, plug it back into the forklift, close the seat cover and your finished.
 
−
 
 
−
'''Note: charging the battery produces hydrogen gas bubbles coming out of the battery.  DO NOT smoke near the battery when the seat lid is up, especially not while charging is going on.
 
−
'''
 
−
==Forklift Vendor==
 
−
 
 
−
=Norlift=
 
−
;Contact/Sales Kevin Hannum
 
−
cell  503 209 0987
 
−
Office 503 659 5438
 
 
                          
 
                          
 
[[Category:Recycling]]
 
[[Category:Recycling]]
 +
[[Category:Procedures]]
 +
[[Category: Environmental Management System]]

Latest revision as of 12:01, 19 July 2014

deletion

This page has been migrated to a document on Free Geek's Google Drive.

Information remaining behind may no longer be relevant.

MIGRATOR:

When you have tagged this page as migrated,
please add a link to the new document on Google Drive.

(Link to new page immediately below.)


Link

General Information about the Forklift

  • Purchased refurbished Clark T15 in August 2006.
  • Vendor: Norlift
  • Sales: Kevin Hannum
    • Norlift 503-659-LIFT
  • Preventative Maintenance (PM) June/December
    • Ken Ferguson 503-519-1541
  • Repairs call Premier Repairservice
    • As of October 2011, the technician is Sean.
    • 503-691-1430

Forklift Maintenance

Forklift Maintenance for Clark T15

Forklift Operator Training

Before a staff member may drive the forklift they must be trained. They have to fill out (with their buddy) the Forklift Training Checklist

  • current certified drivers and date of training:
    • Cliff
      • Trained by Norlift on 11/06/06 (Train the Trainer Program)
      • Re-Certified by Darryl on 11/12/09
    • Liane
      • Trained by Norlift on 11/06/06 (Train the Trainer Program)
      • Re-Certified by Cliff on 11/12/09
    • Darryl
      • Trained by Cliff in October 2007
      • Re-Certified by Liane on 11/12/09
    • John A
      • Trained by Cliff May 2011
      • Certified by Cliff May 2011
Retrieved from "http://wiki.freegeek.org/index.php?title=Forklift&oldid=70733"