Difference between revisions of "Forklift"

From FreekiWiki
Jump to navigation Jump to search
 
 
(47 intermediate revisions by 10 users not shown)
Line 1: Line 1:
−
Maintaining the forklift battery:
+
{{Migrated}}
 +
[https://docs.google.com/document/d/1CYD2i4wfzQAw8IRdfhSEiGvidvNaTSRqUaeKW4gqZdk/edit?usp=sharing Link]
  
−
Once a week (pick one day every week!):
+
'''General Information about the Forklift'''
−
* Lift the seat lid and hold it up with the red latch
 
−
* Ideally do the following with rubber gloves to protect your hands
 
−
* Look inside each of the yellow caps to see the battery acid level
 
−
* Add distilled water to each hole so the level comes just to the
 
−
bottom of the yellow cap tube.  Too much and the battery will
 
−
spew sulferic acid all over the battery top when it charges.
 
−
Not enough and the level will go down and uncover the battery
 
−
plates, causing them to oxidize extra fast.
 
−
* Be sure to use DISTILLED water and a small plastic funnel
 
−
* Clean up with paper towels and wash your hands thoroughly with
 
−
lots of soap to clean off the acid vapors and such.
 
  
−
To charge the battery:
+
* Purchased refurbished Clark T15 in August 2006.
−
# shut down the forklift completely
+
* Vendor: Norlift
−
# open up and latch the seat lid over the battery
+
* Sales: Kevin Hannum
−
# make sure the charger is off (at zero)
+
** Norlift 503-659-LIFT
−
# unplug the huge cable from the forklift and plug it
+
* Preventative Maintenance (PM) June/December
−
into the charger
+
** Ken Ferguson 503-519-1541
−
# turn the charger past 6 hours and then set the
+
* Repairs call Premier Repairservice
−
charging time to the length of time that the forklift
+
** As of October 2011, the technician is Sean.
−
was actually used.  This can be done at the end
+
** 503-691-1430
−
of the day.
+
 
−
# After the charger time is up.  Unplug the battery
+
= Forklift Maintenance =
−
from the charger, plug it back into the forklift,
+
[[Forklift Maintenance for Clark T15]]
−
close the seat cover and your finished.
+
 
−
'''Note: charging the battery produces hydrogen gas
+
= Forklift Operator Training =
−
bubbles coming out of the battery.  DO NOT smoke
+
Before a staff member may drive the forklift they must be trained. They have to fill out (with their buddy) the [[Forklift Training Checklist]]
−
near the battery when the seat lid is up, especially
+
 
−
not while charging is going on.
+
* current certified drivers and date of training:
−
'''
+
** Cliff
 +
*** Trained by Norlift on 11/06/06 (Train the Trainer Program)
 +
*** Re-Certified by Darryl on 11/12/09
 +
** Liane
 +
*** Trained by Norlift on 11/06/06 (Train the Trainer Program)
 +
*** Re-Certified by Cliff on 11/12/09
 +
** Darryl
 +
*** Trained by Cliff in October 2007
 +
*** Re-Certified by Liane on 11/12/09
 +
** John A
 +
*** Trained by Cliff May 2011
 +
*** Certified by Cliff May 2011
 +
                       
 +
[[Category:Recycling]]
 +
[[Category:Procedures]]
 +
[[Category: Environmental Management System]]

Latest revision as of 12:01, 19 July 2014

deletion

This page has been migrated to a document on Free Geek's Google Drive.

Information remaining behind may no longer be relevant.

MIGRATOR:

When you have tagged this page as migrated,
please add a link to the new document on Google Drive.

(Link to new page immediately below.)


Link

General Information about the Forklift

  • Purchased refurbished Clark T15 in August 2006.
  • Vendor: Norlift
  • Sales: Kevin Hannum
    • Norlift 503-659-LIFT
  • Preventative Maintenance (PM) June/December
    • Ken Ferguson 503-519-1541
  • Repairs call Premier Repairservice
    • As of October 2011, the technician is Sean.
    • 503-691-1430

Forklift Maintenance

Forklift Maintenance for Clark T15

Forklift Operator Training

Before a staff member may drive the forklift they must be trained. They have to fill out (with their buddy) the Forklift Training Checklist

  • current certified drivers and date of training:
    • Cliff
      • Trained by Norlift on 11/06/06 (Train the Trainer Program)
      • Re-Certified by Darryl on 11/12/09
    • Liane
      • Trained by Norlift on 11/06/06 (Train the Trainer Program)
      • Re-Certified by Cliff on 11/12/09
    • Darryl
      • Trained by Cliff in October 2007
      • Re-Certified by Liane on 11/12/09
    • John A
      • Trained by Cliff May 2011
      • Certified by Cliff May 2011
Retrieved from "http://wiki.freegeek.org/index.php?title=Forklift&oldid=70733"